They need 2 parts to fix this, one of them is won't be available til mid Feb and the other one is unknown ETA. Does this qualify for lemon law at this point since the car is in shop for 30 days?
In most states you qualify to lemon law your vehicle if three attempts to repair it fail or if it is out of service for 30 or more days. So yeah, I would say yes - your truck probably qualifies.
Mine just did the same thing.. 3700 miles. Was on road trip of 400 miles coming home.. Stop 10 miles shy of home and filled up and when started up got the same thing.. Supposedly later production model, built mid Sept or so.. Frustrating..I was on a road trip and started my car after filling gas. The check engine, grille shutter, drive start control, and system malfunction lights alerts went off. I check my grille shutters and they were open. I ended up driving the car home with no issues or limp mode. The only thing that didn't work was the cruise control and active lane assist.
Supreme Toyota in Hammond told me there were similar issues with the 2022 tundra when it came out and they think they know the fix. They placed me in a new loaner car and have been fantastic so far.
I've had no issues prior to this and am loving the truck. Hope there is a fix soon.
I had mine replaced a couple months ago at my local dealership. I hadn’t had any issues with the original one other than I received a notification telling me to take it to the dealership and have it inspected. They did so and found corrosion due to moisture getting in the connection they replaced it with the new assembly and wiring harness and I haven’t had any trouble. Luckily I didn’t have any trouble with the original one from the factory but against the replaced it out of precaution.
I'm missing a few shutter doors due to my light setup, truck doesn't seem to care. I'm sure you could do without it but it might make it warm up slower..
Had same issue after replacing grill. Found out one of the connectors wasnt fully seated. Pushed it in and it has worked ever since
At the time of the install I did not, but I have since to attempt a "reset" and it does not have any effect.
I disconnected mine and cleaned it with QD electronics cleaner, still no joy. Have a dealer appt Friday now.
I've seen issues like this if you don't disconnect the battery beforehand. Something about not disconnecting the battery but unplugging the sensors makes it go haywire.
